![:roflmao:](http://www.pumapeople.com/forum/public/style_emoticons/default/roflmao.gif)
Daves Car
![:woot2:](http://www.pumapeople.com/forum/public/style_emoticons/default/woot2.gif)
As you can see this one (as they all do) was leaking gas quite bad out the exhaust ports when I removed the manifold..
![Posted Image](http://www.pumapeople.com/stuff/1398204335/gallery_435_252_142335.jpg)
![Posted Image](http://www.pumapeople.com/stuff/1398204335/gallery_435_252_77670.jpg)
the engines always look quite grubby and old once taken out, you just don't realise how much dirt they gather, especially if drive shaft grease has spun out of the boots which makes a god awful mess all over the place..
![:puke:](http://www.pumapeople.com/forum/public/style_emoticons/default/puke.gif)
usual stuff done to this one... I removed the sump sections and had them 'aqua blasted' for a stunning finish... the previous one I did was a sand blast type of finish and thought it looked a little course... changed front and rear crank shaft seals etc etc..
![Posted Image](http://www.pumapeople.com/stuff/1398204335/gallery_435_252_31132.jpg)
cleaned down the engine a bit more and replaced both camshaft seals, water pump timing etc..
![Posted Image](http://www.pumapeople.com/stuff/1398204335/gallery_435_252_180632.jpg)
all timed up again now, bar the final tightening of the bottom pulley which I do on the floor when the flywheel is on and locked up..
![:bleh:](http://www.pumapeople.com/forum/public/style_emoticons/default/bleh.gif)
![Posted Image](http://www.pumapeople.com/stuff/1398204335/gallery_435_252_156708.jpg)
Cam locking bar inserted and cams torqued up to spec by hand...
![Posted Image](http://www.pumapeople.com/stuff/1398204335/gallery_435_252_163510.jpg)
also changed the idle pulley and Aux tensioner (which was quite expensive) to give a super smooth Aux drive... both were quite rough and dry sounding..
![Posted Image](http://www.pumapeople.com/stuff/1398204335/gallery_435_252_6195.jpg)
All done and ready to rock!... new bottom hose too...
![:cool:](http://www.pumapeople.com/forum/public/style_emoticons/default/ja_cool.gif)
![:cool:](http://www.pumapeople.com/forum/public/style_emoticons/default/ja_cool.gif)
![:cool:](http://www.pumapeople.com/forum/public/style_emoticons/default/ja_cool.gif)
![:cool:](http://www.pumapeople.com/forum/public/style_emoticons/default/ja_cool.gif)
![Posted Image](http://www.pumapeople.com/stuff/1398204335/gallery_435_252_14844.jpg)
Chris
FRP453